Changes in the characteristics of silicon photovoltaic cells of solar arrays after current overloads
Abstract
Recently, much attention has been paid to the study of the influence of current overloads and local overheating on the degradation of the electrical characteristics of the photovoltaic components of solar arrays. First of all, it is connected with the tasks of increasing the reliability and durability of the operation of such renewable sources of electrical energy. Such studies are of particular interest due to the recent emergence of new methods and devices for improving the reliability of solar arrays by isolating inactive (defective or shaded) areas of their photovoltaic components (photovoltaic cells and photovoltaic modules).
This paper presents the research results on the influence of current overloads on the current-voltage and volt-watt characteristics and the electrical parameters of photovoltaic cells of solar arrays based on monocrystalline silicon.
The testing was performed using the cyclic current overload mode, which is the flow of electric breakdown current passed through the back-turned diode of a photovoltaic cell for several seconds. After that, the photovoltaic cell was cooled to room temperature, and then its current-voltage and volt-watt characteristics were measured.
The degradation (decrease) of all the basic electrical parameters of photovoltaic cells (open-circuit voltage, short-circuit current, filling factor of the current-voltage characteristic, and maximum power) has been established. The additive nature of the changes and the average relative decrease of the indicated electrical parameters for one breakdown cycle are determined. Comparison of the response time range of the PolySwitch fuses with the breakdown durations of photovoltaic cells is performed. The conclusion is drawn about the prospect of using such resettable fuses as protection in emergency situations that are associated with current overloads in solar arrays.
References
Kӧntges M., Kurtz S., Packard C. et. al. Review of failures of photovoltaic modules. IEA PVPS Task 13, 2014, 132 p.
United Solar Technologies / [Electronic resource]. Access mode: http://ust.su/solar/media/section-inner17/1595/ 16.07.2109 (Rus)
Tonkoshkur O.S., Nakashydze L. V. [Problems of reliability of photovoltaic components of solar arrays]. Vidnovliuvana Enerhetyka (Renewable energy), 2018, no. 3, pp. 21–31. (Ukr)
Radziemska Е. Effect of temperature on dark current characteristics of silicon solar cells and diodes. International Journal of Energy Research, 2006, vol. 30, iss. 2, pp. 127–134. https://doi.org/10.1002/er.1113
Flammini M. G., Debernardi N., Le Ster M. et. al. The influence of heating time and temperature on the properties of CIGSSe solar cells. International Journal of Photoenergy, 2016, vol. 2016, article ID 4089369, 7 p. http://dx.doi.org/10.1155/2016/4089369
Ivanchenko A.V., Mazurik S.V., Tonkoshkur A.S. [Inve stigation of the characteristics of silicon photovoltaic converters of solar batteries in case of overheating]. Tekhnologiya i Konstruirovanie v Elektronnoi Apparature, 2018, no. 4, pp.14–20. http://dx.doi.org/10.15222/TKEA2018.4.14 (Rus)
Gudkova A. V., Gubin S. V., Belokon’ V. I. [Thermal stabilization of solar cells for current-voltage characteristics measurement with the pulsed light source]. Otkrytyye informatsionnyye i komp’yuternyye integrirovannyye tekhnologii, 2012, no. 57, pp. 187–196. (Rus)
Tonkoshkur A. S., Ivanchenko A. V., Nakashydze L. V., Mazurik S. V. [Application of resettable elements for electrical protection of solar batteries]. Tekhnologiya i Konstruirovanie v Elektronnoi Apparature, 2018, no. 1, pp. 43–49. http://dx.doi.org/10.15222/TKEA2018.1.43 (Rus).
Gavrikov V. [Resettable PTC fuses for protection of current overload]. Novosti Elektroniki, 2014, no. 12, pp. 11–15. (Rus) 10. Bishop J. W. Microplasma breakdown and hot-spots in silicon solar cells. Solar Cells, 1989, vol. 26, iss. 4, pp. 335–349. https://doi.org/10.1016/0379-6787(89)90093-8
Breitenstein O., Bauer J., Bothe K. et al. Understanding junction breakdown in multicrystalline solar cells. Journal of Applied Physics, 2011, vol. 109, iss. 7, article ID 071101, 10 p. https://doi.org/10.1063/1.3562200
Ivanchenko A. V., Tonkoshkur A. S., Mazurik S. V. Application of “PolySwitch” fuses for the limitation of current overloads in photovoltaic systems of solar arrays. Journal of Physics and Electronics, 2018. vol. 26, no. 1, pp. 77–82. https://doi.org/10.15421/331813
Herrmann W., Adrian M., Wiesner W. Operational behaviour of commercial solar cells under reverse biased conditions./ Proceedings of the Second World Conference on Photovoltaic Solar Energy Conversion, Austria, Vienna, 1998, pp. 2357–2359.
Nakashidze L. V., Knysh L. I. [Methodology for determining the composition and circuit design of solar photovoltaic equipments]. Aviatsionno-Kosmicheskaya Tekhnika i Tekhnologiya, 2008, no. 10 (57), pp. 100–104. (Rus)
Tonkoshkur O. S., Ivanchenko O. V., Nakashydze L. V., Mazuryk S. V. [Protection of solar arrays from electrical overloads: monograph] Zakhyst Sonyachnykh Batarey vid Elektrychnykh Perevantazhen'. Dnipro, Ltd. „AKTsENT PP”, 2018, 113 p. (Ukr)]
Koltun M. M. [Optics and Metrology of Solar Elements] Optika i Metrologiya Solnechnykh Elementov, Moscow, Nauka, 1985, 280 p. (Rus)
Tonkoshkur A. S. [Schematic technologies for improving the reliability of renewable energy sources based on solar arrays using functional electronics elements]. Mater. Of the VІI Int. Scientific-Practical Conference “Development of Business-Analytics, Accounting and Taxation in the Conditions of Globalization, Aggravation of Energy Problems”, Ukraine, Dnipro, 2019, pp. 210–212. (Ukr)
Trusov V. A., Gusev A. M. [Elements of protection of electrical circuits against overvoltages and overcurrents]. Proceedings of International Symposium “Reliability and Quality”, 2011, vol. 2, pp. 221–224. (Rus)
Copyright (c) 2019 Ivanchenko A. V., Tonkoshkur A. S.
This work is licensed under a Creative Commons Attribution 4.0 International License.
